Upper Keys
Glass Garage Doors in Tavernier
A glass garage door is an aluminum frame with glass panes, and it is often heavier than it looks. People search it for one cracked pane, a twisted frame, or springs that strain under the weight. A single cracked pane in a straight frame can be glass only. A twisted frame is a different repair, and the glass by itself is not a wind rating. The springs still have to match the combined weight of the frame and the panes.
Cracked pane or twisted frame
A single cracked pane, with the frame still square, can be replaced as glass. A twisted frame shows up as a door that racks, binds, or will not sit in the track. The aluminum does not rust the way the steel hinges and rollers on the same door do. Those steel parts can pit while the aluminum frame still looks quite clean. Weight is easy to underestimate, and the springs have to match what the door actually weighs once hung.
What you can check
Look along the frame for a twist, and note which pane is cracked. See whether the steel hinges show orange dust while the aluminum frame stays bright. Do not remove a cracked pane or loosen any frame screws while the springs are still wound. Never touch the springs, the cables, or the set screws to get a closer look at them. A photo of the cracked pane and one of the whole door show whether the frame is still square.
Glass weight and the springs
The visit replaces a pane when the frame is straight and the glass is the only failure. A twisted frame is repaired or the door is replaced, because new glass will not straighten it. Springs are checked against the real weight, including the glass and the frame. The opener is kept if it lifts that weight without straining after the door is balanced. Steel hinges and rollers are replaced when they are pitted, even if the aluminum frame looks fine.
Frame glass and steel hardware
The frame carries the glass, and a racked corner throws every roller out of line. Hinge screws into aluminum need the right bite, or the hinge pulls out of the frame. A pane is ordered to the opening in the frame, not to a rough guess from the floor. Seals around the glass are separate from the bottom weather seal on the door. Balance comes after the glass and any new hinges are on, so the final weight is known.
Damp air and storms
A basin lot in Tavernier salts the hinges on a glass door sooner than an inland lot does. Humidity films the glass and the photo eyes and can look like a door that will not close. Salt reaches those steel hinges and rollers sooner when the opening sits closer to the water. Storms drive rain at the seals around each pane and at the bottom of the frame. The aluminum frame stays bright while the steel hardware still needs replacing.
Request this visit.
Call (645) 256-1794 about this door.
We answer any hour Sunday through Friday.
Saturday stays closed.
Keys Door Co is family-owned, local, and insured.
We have worked this coast for over ten years.
Common questions
Can one cracked pane be replaced by itself?
One cracked pane can be replaced when the aluminum around it is still square. A twisted frame is a different repair, because new glass will not pull it square. The springs are checked for the weight of the glass and the frame together.
Does the glass make the door wind rated?
The panes do not carry a wind rating for the opening on their own. A rating belongs to a tested assembly, which is a separate order from a pane. This visit replaces glass, frame problems, and the steel hardware that has pitted.
Why do the hinges rust if the frame looks clean?
Aluminum does not rust the way the steel hinges and rollers on the same door do. Those steel parts can pit in damp air while the frame stays bright. Pitted hinges and rollers are replaced even when the aluminum still looks new.
Request service
Name the street and whether the door is up, down, or stuck.
- Repairs and replacement parts
- Openers and controls
- New garage doors